发货地: 山东济宁
SGR1922鍋爐運行除垢劑(清洗劑),是根據鍋爐結垢特點而開發出來的一款專用除垢產品;可以適用于化工企業、供熱公司、自備電廠等鍋爐系統垢污清除。
1. 鍋爐運行除垢劑介紹
SGR1922鍋爐運行除垢劑(清洗劑),是根據鍋爐結垢特點而開發出來的一款專用除垢產品;可以適用于化工企業、供熱公司、自備電廠等鍋爐系統垢污清除。SGR1922是一種弱堿性產品,由螯合劑、增溶劑、滲透劑、分散劑等成份組成,可高效清除碳酸鹽垢、硫酸鹽垢、鐵垢,而且也能抑制垢污的二次沉積,提高鍋爐運轉安全性。本產品亦可以作為鍋爐阻垢劑使用。
2. 鍋爐運行除垢劑性能指標
3. 鍋爐運行除垢劑使用方法
SGR1922運行鍋爐除垢劑,具體使用方法與用量應根據現場具體工況確定,建議如下:
(1)第一次使用本產品,根據鍋爐水溶劑添加1500.0ppm-2500.0ppm,并適當提高鍋爐排污周期,注意清洗狀況,以免脫落的垢污堵塞排污口;
(2)前期,根據鍋爐補水,添加1500.0ppm每噸補水的SGR-1922運行鍋爐除垢劑,每班排污一次,排污率一般8.0~10.0%,排污時應該打開所有排污閥門;
(3)除垢周期一般14天至30天,如果高量較大適當延長除垢時間;根據除垢情況,后期添加量可以降為每噸補水100.0ppm-500.0ppm甚至更低;
(4)為提高系統穩定運行,本產品作為水體阻垢劑使用,一般添加補水量的30.0ppm-50.0ppm.
4. 鍋爐運行除垢劑包裝與貯運
SGR1922,一般采用25.0L塑料桶包裝或根據顧客要求而定,陰涼、干燥、通風放置。
5. 鍋爐運行除垢劑安全與防護
SGR1922運行鍋爐除垢劑為弱堿性產品,操作時注意勞動保護,接觸后用大量清水沖洗;有效儲存期12.0月以上。
Boiler online descaling agent manual SGR1922
product presentation
SGR1922 Boiler operation scaling agent (cleaning agent) is a special scaling product developed according to the characteristics of boiler scale; it can be applied to chemical enterprises, heating companies, self-provided power plants and other boiler system scale removal. SGR1922 Is an alkaline product, composed of chelating agent, solvent, penetration agent, dispersant and other components, can effectively remove carbonate scale, sulfate scale, iron scale, but also can inhibit the secondary deposition of dirt, improve the safety of boiler operation. This product can also be used as a boiler scale inhibitor.
performance index
product appearance | Light yellow and clear liquid |
PH (1% aqueous solution) | ≥ 7.0 |
Density (20℃) | ≥1.15g/cm3 |
usage method
SGR1922 Operating boiler scale removal agent, the specific use method and dosage should be determined according to the specific site conditions, suggestions are as follows:
(1) For the first time to use this product, add 1500.0ppm-2500.0ppm according to the boiler water volume, and appropriately improve the boiler sewage cycle, pay attention to the cleaning condition, so as not to shed the dirt and block the sewage outlet;
(2) In the early stage, according to the boiler water replenishment, add 1500.0ppm SGR1922 boiler scale removal agent per ton, sewage discharge once per shift, the sewage rate is generally 8.0~10.0%, all sewage valves should be opened when sewage;
(3) The descaling period is generally 14 to 30 days, if the high amount is appropriately extended; according to the descaling situation, the later added amount can be reduced to 100.0ppm-500.0ppm or even lower per ton;
(4) In order to improve the stable operation of the system, this product is used as a water scale inhibitor, generally adding 30.0ppm-50.0ppm of water supplement.
Packaging and storage
SGR-1922, generally using 25.0L plastic bucket packaging or according to customer requirements, cool, dry, ventilated placement.
Safety and protection
SGR-1922 Operating boiler scale remover is weak alkaline product, pay attention to labor protection during operation, rinse with plenty of water after contact; the effective storage period is more than 12.0 months.
加熱1小時后